1992 Rofin-Sinar RS-6000 — UMS record #15355
WELDERS, LASER
Historical UMS record #15355
Specifications
PREFORMANCE
Wave Length10.6 microns
POWER OUTPUT
Guaranteed6000 Watts
Range (Typical)600 To 6600 W
Stability(Long Term At Rated Power Output)+/-2%
Fluctuation Of Cooling Water+/- 0.5 C (+/-1F)
BEAM QUALITY
Diameterapp. 30mm
Divergence</-1.5 Mrad Full Angle
Pointing Stability</-0.15 Mrad
ModeTem 20 @Rated Output
Mode (Using Mode Aperture Linear @45 Degrees To HoTem 00@1500W
ELECTRICAL EXCITATION
Frequency (RF)27.12 MHz
PULSE CHARACTERRICTICS
Frequency0-25 kHz
Width20 us-cw
SUPER PULSE CHARACT
Frequency0-10 mHz
Width20-500 us
Keying Ratio</-25%
Peak Power Output</-20kW
ELECTRICAL
Service380 VAC +/-5%/60 Hz/3
Power ConsuptionMax. 90kW
Current ConsumptionMax. 150A/Phase
Fuse160A Inert For 380 VAC
COOLING WATER
Flow rate52 GPM
Supply PressureMax. 7000hPa(100 PSI)
Pressure Drop Across Lasertyp3500 hPa (51 PSI)
Back PressureMax. 1000hPa (15 PSI)
Refrigeration CapacityMin. 90kW
Hardness</-50 Microns
Temperature64 To 72 Degrees
Temperature Stability+/- 1 Degree F
COMPRESS AIR
Consumption0.1 N1 Per Shutter Operation
QualityFree Of Moisture
Pressure65 To 87 PSI
LASER GAS
Consumption (He 140N1/h (4,9 scfh))Purity 4.6
Consumption (N2 45N1/h (1,6 scfh))Purity 4.6
Consumption (CO2 61/h (0,2 scfh))Purity 4.5
Pressure65 To 87 PSI
AMBIENT TEMP
Range50 To 86 Degrees
PROTECTION
ClassIP54
WEIGHTS
Pump Unit5886 Lbs.
Power Supply4034 Lbs.
Control Console683 Lbs.
Equipped With
6000 Watt Capacity Laser Head
Resonator
MechanicalShutter (Water Cooled)
Vacuum Unit
Cooling Circuit For RF Unit
Simatic S5-115 U Programmable Logic Controller With:
Resontor Pressure Reading
Laser Output Power (Actual Value)
Laser Output Power (Set Value)
Selected Operating Mode (Normal or Superpulse)
State Of High-Voltage Supply
Keyboard
Monitor
Failure/Faults Messages
RF Units:
RF Oscillator
RF Power Amplifer
RF Final Stage
Power Supply
Anode Power Supply
Meter Panel
Process Control Unit
Amplitude Control & Limiter
Laser Gas Supply (Laser Gases h#e, N2 & CO2)
HISTORY
This Laser has many uses. It was being used to laser weld two gears for the transmission
of an Saturn Automobile.
NOTE
There are over $234,000.00 in new spare parts kept on hand by Saturn that are available
subject to offer from buyer and approval.